Event Notification Report for August 20, 2001
U.S. Nuclear Regulatory Commission
Operations Center
Event Reports For
08/17/2001 - 08/20/2001
** EVENT NUMBERS **
38119 38214 38218 38219 38220 38221
!!!!!!!!! THIS EVENT HAS BEEN RETRACTED. THIS EVENT HAS BEEN RETRACTED !!!!!!!
+------------------------------------------------------------------------------+
|Power Reactor |Event Number: 38119 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| FACILITY: FERMI REGION: 3 |NOTIFICATION DATE: 07/05/2001|
| UNIT: [2] [] [] STATE: MI |NOTIFICATION TIME: 16:03[EDT]|
| RXTYPE: [2] GE-4 |EVENT DATE: 07/05/2001|
+------------------------------------------------+EVENT TIME: 10:00[EDT]|
| NRC NOTIFIED BY: COSEI |LAST UPDATE DATE: 08/17/2001|
| HQ OPS OFFICER: CHAUNCEY GOULD +-----------------------------+
+------------------------------------------------+PERSON ORGANIZATION |
|EMERGENCY CLASS: NON EMERGENCY |ROGER LANKSBURY R3 |
|10 CFR SECTION: | |
|AINA 50.72(b)(3)(v)(A) POT UNABLE TO SAFE SD | |
| | |
| | |
| | |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|UNIT |SCRAM CODE|RX CRIT|INIT PWR| INIT RX MODE |CURR PWR| CURR RX MODE |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|2 N Y 100 Power Operation |100 Power Operation |
| | |
| | |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| NON-CONSERVATIVE ANALYSIS FOR OPRM SCRAM SETPOINTS |
| |
| On July 5, 2001, Detroit Edison received confirmation from General Electric |
| of a non-conservative analysis that supports Operation Power Range Monitor |
| (OPRM) scram setpoints. The non-conservative analysis is generic and been |
| determined to affect Fermi 2. The OPRM had been conservatively declared |
| inoperable on June 27, 2001, at 1333 hours as a result of preliminary |
| notification by General Electric. |
| |
| The consequences of the non-conservative analysis are that the associated |
| OPRM Reactor Protective System (RPS) scram setpoints are non-conservative. |
| The non-conservative RPS setpoints may result in violating the Minimum |
| Critical Power Ratio (MCPR) safety limit during a thermal-hydraulic |
| instability. |
| |
| All OPRM channels have been declared inoperable. Technical Specification |
| 3.3.1.1 Action J requires an alternate method of detecting and suppressing |
| thermal-hydraulic instabilities to be implemented within 12 hours. |
| Alternate methods have been established, thus, the Technical Specification |
| required action is satisfied. Fermi 2 has 120 days to restore the OPRMs to |
| an operable condition. |
| |
| This initial report is being made in accordance with 10CFR50.72 (B)(3)(V)(A) |
| as a condition that could have prevented the fulfillment of the safety |
| function of a system needed to shutdown the reactor. |
| |
| See EN #38104, GE Nuclear Energy 10CFR21 report. |
| |
| The NRC Resident Inspector will be notified. |
| |
| * * * RETRACTED AT 1443 EDT ON 8/17/2001 BY PATRICK FALLON TO FANGIE JONES * |
| * * |
| |
| The licensee is retracting the event notification. |
| |
| "Subsequent design calculations have concluded that there was sufficient |
| conservatism in the existing OPRM RPS scram setpoints to accommodate |
| corrections for the non-conservative analysis performed by General Electric, |
| which was the subject of their 10 CFR 21 Notification dated June 29, 2001 |
| (SC01 -01), and still provide protection for the Minimum Critical Power |
| Ratio (MCPR) Safety Limit during a thermal-hydraulic instability throughout |
| the current operating cycle. The OPRM RPS scram function was not required to |
| be operable prior to the current operating cycle. Since the existing OPRM |
| RPS scram setpoints have been shown to be set conservatively, the OPRM |
| system was operable, and therefore no situation existed which was |
| reportable." |
| |
| The licensee has notified the NRC Resident Inspector. The R3DO (Thomas |
| Kozak) has been notified. |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
|Power Reactor |Event Number: 38214 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| FACILITY: LIMERICK REGION: 1 |NOTIFICATION DATE: 08/16/2001|
| UNIT: [1] [2] [] STATE: PA |NOTIFICATION TIME: 11:40[EDT]|
| RXTYPE: [1] GE-4,[2] GE-4 |EVENT DATE: 08/16/2001|
+------------------------------------------------+EVENT TIME: 09:25[EDT]|
| NRC NOTIFIED BY: PETER ORPHANOS |LAST UPDATE DATE: 08/17/2001|
| HQ OPS OFFICER: FANGIE JONES +-----------------------------+
+------------------------------------------------+PERSON ORGANIZATION |
|EMERGENCY CLASS: NON EMERGENCY |RONALD BELLAMY R1 |
|10 CFR SECTION: | |
|ACOM 50.72(b)(3)(xiii) LOSS COMM/ASMT/RESPONSE| |
| | |
| | |
| | |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|UNIT |SCRAM CODE|RX CRIT|INIT PWR| INIT RX MODE |CURR PWR| CURR RX MODE |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|1 N Y 100 Power Operation |100 Power Operation |
|2 N Y 100 Power Operation |100 Power Operation |
| | |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| ALL EMERGENCY OFFSITE SIRENS INOPERABLE |
| |
| The licensee determined that all 16 Emergency Offsite Sirens were |
| inoperable. The exact cause of the failure is unknown and a plan is being |
| developed to repair the sirens. |
| |
| The licensee notified the NRC Resident Inspector and intends to notify the |
| state and local authorities. |
| |
| * * * UPDATED AT 1735 EDT ON 8/16/2001 BY PETER ORPHANOS TO FANGIE JONES * * |
| * |
| |
| "As of 1300 August 16, 2001 163 of 165 Limerick Generating Station Emergency |
| Offsite Sirens are determined to be functional. |
| |
| "A plan has been developed and investigation continues into the cause of the |
| inoperability of the sirens." |
| |
| The licensee notified the NRC Resident Inspector. The R1DO (William Ruland) |
| has been notified. |
| |
| * * * UPDATED AT 1751 EDT ON 8/17/2001 BY GREG SOSSON TO FANGIE JONES * * * |
| |
| "As of 17:30, August 17, 2001 163 of 165 Limerick Generating Station |
| Emergency Offsite Sirens remain fully functional The status of the sirens is |
| being continuously monitored as part of the troubleshooting plan |
| |
| "There was one 20 minute interruption of the siren system early this morning |
| Since then, the sirens have continued to function properly. |
| |
| "The investigation and troubleshooting will continue through the weekend. |
| |
| "Contingency public notification plans have been confirmed to be in place |
| with the counties." |
| |
| The licensee notified the NRC Resident Inspector. The R1DO (Ronald Bellamy) |
| has been notified. |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
|Power Reactor |Event Number: 38218 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| FACILITY: PEACH BOTTOM REGION: 1 |NOTIFICATION DATE: 08/17/2001|
| UNIT: [2] [3] [] STATE: PA |NOTIFICATION TIME: 00:31[EDT]|
| RXTYPE: [2] GE-4,[3] GE-4 |EVENT DATE: 08/16/2001|
+------------------------------------------------+EVENT TIME: 23:25[EDT]|
| NRC NOTIFIED BY: STEVE TANNER |LAST UPDATE DATE: 08/17/2001|
| HQ OPS OFFICER: STEVE SANDIN +-----------------------------+
+------------------------------------------------+PERSON ORGANIZATION |
|EMERGENCY CLASS: NON EMERGENCY |WILLIAM RULAND R1 |
|10 CFR SECTION: | |
|ACOM 50.72(b)(3)(xiii) LOSS COMM/ASMT/RESPONSE| |
| | |
| | |
| | |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|UNIT |SCRAM CODE|RX CRIT|INIT PWR| INIT RX MODE |CURR PWR| CURR RX MODE |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|2 N Y 100 Power Operation |100 Power Operation |
|3 N Y 82 Power Operation |82 Power Operation |
| | |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| LOSS OF EMERGENCY SIREN REMOTE ACTUATION CAPABILITY |
| |
| "Omni phone system was lost resulting in a loss of Emergency Siren remote |
| actuation control. Power was lost 8/16/01 22:25 EDT and restored 8/16/01 |
| 23:55 EDT. Per reportability manual ID# E-02 and Event# SAF 1.10, loss of |
| assessment capability is reportable after 8 hours, but loss of greater than |
| 25% of the sirens for more than one hour constitutes immediate |
| notification. |
| |
| "The omni phone system was lost due to the associated battery voltage |
| becoming too low to support system operation. This was caused by a |
| temporary battery charger installed in place of the normal charger (due to a |
| failed transformer) not maintaining the battery adequately charged. |
| Immediate omni system recovery was effected using available AC power from an |
| alternate source to power up the equipment. Long term plans are to replace |
| the failed transformer and return the normal charger to service." |
| |
| The licensee informed the NRC resident inspector and will inform state/local |
| agencies. |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
|Other Nuclear Material |Event Number: 38219 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| REP ORG: McMINN'S ASPHALT CO., INC. |NOTIFICATION DATE: 08/17/2001|
|LICENSEE: McMINN'S ASPHALT CO., INC. |NOTIFICATION TIME: 04:59[EDT]|
| CITY: MANHEIM REGION: 1 |EVENT DATE: 08/17/2001|
| COUNTY: STATE: PA |EVENT TIME: 00:30[EDT]|
|LICENSE#: 371965901 AGREEMENT: N |LAST UPDATE DATE: 08/17/2001|
| DOCKET: |+----------------------------+
| |PERSON ORGANIZATION |
| |WILLIAM RULAND R1 |
| |BRIAN SMITH NMSS |
+------------------------------------------------+ |
| NRC NOTIFIED BY: GARY LUTZ | |
| HQ OPS OFFICER: STEVE SANDIN | |
+------------------------------------------------+ |
|EMERGENCY CLASS: NON EMERGENCY | |
|10 CFR SECTION: | |
|NINF INFORMATION ONLY | |
| | |
| | |
| | |
| | |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| TROXLER GAUGE DAMAGED BY VEHICLE AT CONSTRUCTION SITE |
| |
| At 0030EDT on 8/17/01 a light pickup truck struck a Troxler gauge at a road |
| construction project on State Road 340 in Lancaster, PA. The East Lampeter |
| Police Department responded (Incident # 01-414) briefly closing traffic. |
| The RSO surveyed the device and confirmed that the sealed source was intact |
| prior to removal. The Troxler is a model 4640B containing an 8-millicurie |
| Cs-137 source. The licensee is returning the device to the manufacturer's |
| service center in Timonium, MD for inspection and repair. |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
|Power Reactor |Event Number: 38220 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| FACILITY: PALO VERDE REGION: 4 |NOTIFICATION DATE: 08/17/2001|
| UNIT: [] [] [3] STATE: AZ |NOTIFICATION TIME: 21:19[EDT]|
| RXTYPE: [1] CE,[2] CE,[3] CE |EVENT DATE: 08/17/2001|
+------------------------------------------------+EVENT TIME: 16:45[MST]|
| NRC NOTIFIED BY: RUSSELL STROUD |LAST UPDATE DATE: 08/17/2001|
| HQ OPS OFFICER: FANGIE JONES +-----------------------------+
+------------------------------------------------+PERSON ORGANIZATION |
|EMERGENCY CLASS: NON EMERGENCY |ANTHONY GODY R4 |
|10 CFR SECTION: | |
|ASHU 50.72(b)(2)(i) PLANT S/D REQD BY TS | |
| | |
| | |
| | |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|UNIT |SCRAM CODE|RX CRIT|INIT PWR| INIT RX MODE |CURR PWR| CURR RX MODE |
+-----+----------+-------+--------+-----------------+--------+-----------------+
| | |
| | |
|3 N Y 97 Power Operation |55 Power Operation |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| TECH SPEC REQUIRED SHUTDOWN DUE A LEAK FROM THE FUEL POOL INTO CONTAINMENT |
| |
| "On August 17, 2001 at approximately 1245 MST, Palo Verde Unit 3 was at |
| approximately 97 percent power and at normal RCS temperature and pressure, |
| when operations personnel detected an increase in containment sump level. |
| Subsequent investigation revealed the quick operating closure device (QOCD) |
| (EQID #PCE-M01) that isolates the containment from the fuel transfer tube |
| was leaking by borated water from the fuel transfer canal at approximately 1 |
| gallon per minute. Operations personnel entered TS LOC 3.6.1 Containment, |
| Required Action A. This action requires the containment be restored to an |
| operable status within one hour. |
| |
| "Since containment integrity was uncertain, and compliance with LCD 3.6 1 |
| Required Action A could not be met within one hour, operations personnel |
| entered LCD 3.6.1, Required Action 8.1 at 1345 MST. Required Action B.1 |
| requires the unit be placed in Mode 3 in 6 hours, and Required Action 8.2 |
| requires the unit be placed in Mode 5 within 36 hours, Following operations |
| briefings, shutdown was commenced at approximately 1645 MST. At this time, |
| Palo Verde Unit 3 is continuing to reduce power in an orderly manner and |
| anticipates being in Mode 3 (Hot Standby) by approximately 1845 MST. |
| |
| "There were no other component failures, testing or work in progress that |
| contributed to this event. The QOCD leak is allowing 4400 part per million |
| borated water into the containment. There has been no release of |
| radioactivity to the environment and no impact to the health and safety of |
| the public has occurred or is anticipated. There is no elevated RCS activity |
| and heat removal is via normal steaming to the main turbine condenser. The |
| electric grid is stable." |
| |
| The licensee informed the NRC Resident Inspector. |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
|Power Reactor |Event Number: 38221 |
+------------------------------------------------------------------------------+
+------------------------------------------------------------------------------+
| FACILITY: CALLAWAY REGION: 4 |NOTIFICATION DATE: 08/18/2001|
| UNIT: [1] [] [] STATE: MO |NOTIFICATION TIME: 08:23[EDT]|
| RXTYPE: [1] W-4-LP |EVENT DATE: 08/18/2001|
+------------------------------------------------+EVENT TIME: 05:30[CDT]|
| NRC NOTIFIED BY: GARY OHMSTEAD |LAST UPDATE DATE: 08/18/2001|
| HQ OPS OFFICER: BOB STRANSKY +-----------------------------+
+------------------------------------------------+PERSON ORGANIZATION |
|EMERGENCY CLASS: NON EMERGENCY |ANTHONY GODY R4 |
|10 CFR SECTION: | |
|ACOM 50.72(b)(3)(xiii) LOSS COMM/ASMT/RESPONSE| |
| | |
| | |
| | |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|UNIT |SCRAM CODE|RX CRIT|INIT PWR| INIT RX MODE |CURR PWR| CURR RX MODE |
+-----+----------+-------+--------+-----------------+--------+-----------------+
|1 N Y 100 Power Operation |100 Power Operation |
| | |
| | |
+------------------------------------------------------------------------------+
EVENT TEXT
+------------------------------------------------------------------------------+
| TECHNICAL SUPPORT CENTER UNAVAILABLE |
| |
| The licensee deenergized electrical buses supplying the Technical Support |
| Center in order to perform regularly scheduled maintenance to a circuit |
| breaker and transformer. Contingency plans are in place in the event that |
| the TSC becomes necessary to support onsite activities. The licensee |
| estimates that power will be restored to the facility within 12 hours. The |
| NRC resident inspector has been informed of this notification. |
+------------------------------------------------------------------------------+
Page Last Reviewed/Updated Thursday, March 25, 2021